After the Gas Tricycles battery is repaired, the Gas Tricycles battery pack must be assembled, otherwise the repair effect of the Passenger Tricycles will not be achieved. The smaller the capacity difference of the Gas Tricycles batteries connected in series during assembly, the better. The difference between medium and high capacity and low capacity should be less than 6%, the capacity distribution should be reasonable and continuous, avoid sudden high and low, and the voltage difference of the open circuit terminal of the Gas Tricycles battery should be within ±0.5V.
1. Three-wheel motorcycle battery matching method
Before assembly, the charging and discharging conditions of the Gas Tricycles battery should be fully checked in advance. After three chargings and two dischargings, the curve and capacity are exactly the same, and the open circuit voltage after charging and discharging is also the same. If the Gas Tricycles battery is assembled into a group, Their synchronization is definitely good in use. When the discharge is terminated at the same time and the charge is fully charged at the same time, the maximum energy can be fully exerted, and the last time reaches the end of life.
2. How to replace the battery when matching
(1) Replace the old three-wheel motorcycle battery with the old three-wheel motorcycle battery: choose an old three-wheel motorcycle battery that has not been scrapped, and match it with the remaining two three-wheel motorcycle batteries in the original group. The open circuit voltage is the same as or close to the remaining two tricycle batteries in the original group, and will continue to be used after assembly until the life of the tricycle battery ends.
It is unscientific and uneconomical to replace the old Gas Tricycles battery with a new Gas Tricycles battery. The old and new Gas Tricycles batteries will never work synchronously. Not only the characteristics are very different, but also the charging and discharging terminal voltage is also different. Capacity is a big issue, and replacing old three-wheeler batteries with new ones is not feasible.
(2) Trade in the old for the new: the service life of the Gas Tricycles battery pack is less than 1/3 of the annual life, and even only takes a short time. If a Gas Tricycles battery becomes a problem and cannot be used after identification, it should In the above situation, choose to replace the new Gas Tricycles battery or the used new Gas Tricycles battery, but the difference should be reduced. The capacity difference is within 1%, and the voltage difference is within ±0.5V. The better the service life and charging and discharging performance of the motorcycle battery, the better the mileage of the Gas Tricycles can be guaranteed.
The service life of the Passenger Tricycles after repair is a major issue related to the significance of Passenger Tricycles repair, which is closely related to the Passenger Tricycles repair instrument used, the condition of the tricycle battery, and the repair method used.
The first is the repair effect of the Passenger Tricycles repair instrument. Secondly, the repair method of the Passenger Tricycles is also very important. The correct method is to use a special repair agent for the battery, remove the vulcanization with a pulse repair instrument, and then adjust it according to the actual capacity of the battery to prolong the service life of the battery. service life.
In addition, most of the scrapped Gas Tricycles batteries are caused by the sulfation of the Gas Tricycles battery, which leads to a decrease in capacity. This is also the time for the Passenger Tricycles to be repaired. Lifespan of a motorcycle battery.